Austarion

hey all,

does anyone have a starion that does not leak oil i swear i cant stop it coming out its ridiculous is it stopable?!

Glen GSR's starion doesn't leak.

I think its called crankcase pressure.
And the puney little pcv valve doesnt help
Maybe a big pipe into a catch tank.

And the puney little pcv valve doesnt help

whats this valve u talk of? the one way valve on the head?

iXNAY wrote:

And the puney little pcv valve doesnt help

whats this valve u talk of? the one way valve on the head?

Yep.

how can u make it bigger its a tapped thread isn;t it?

will putting a reducer in there with a bigger valve on it make it any better?

also will putting a bigger pipe from the sump too the seperator help any?

regards

My old motor used to leak from just about every part of the motor. It even used to blow oil threw the breather hose into the air box which then would leak out the cold air hole I cut in it, then running into the chassis rail and leaking back out the chassis drain hole half way down the car. So when I built a new motor I replaced every single Gasket ensured all surfaces were clean and flat and used high quality permatec and silicon. Now it drips one tiny little drip a day just to piss me off I think. I don’t know where from I don’t know how it’s possible; I think it’s just the way Starions are!

spend 1500 bux on a full rebuild use gasket goe on the roccer cover coz that leaks is ur rear and front crank seal leaks because of the grove in the crank left over from the seal goin round and round...hammer the seal in half way befor the grove the your garenteed no leaks...most of the time they put a sleave over it but thats the cheap way out,and 1500 will get u every thing u need plus crank ground down and linished....cromeolly rings bed in fast say 500km non synthetic oil then bobs ye fuking uncle...get the balance shfts removed get the oil jernal blockd up sweet more oil pressure have fun

ive got a little breather filter on mine
k and n $35

2 of mine don't leak a drop, the other leaks a little - only requires a cleanup every 3 or 4 months. Maybe I'm just lucky

The only place my Starion leaks form is the rear of the rocker cover (can't be bothered fixin it cos its minimal) and it flows out of the power steering pump and drag box, can't drive more than 40kms without a refill!!!!!!

Cookiemonster wrote:Glen GSR's starion doesn't leak.

Glen GSR's starion doesn't do much really. Kind of just sits there all sad-like. Its the undercoat grey that makes it look bad. :(

Mine didn't used to leak....Was perfect. I went over it every day, just to make sure